A novel Trichoderma reesei mutant RP698 with enhanced cellulase production.

A new strain of Trichoderma reesei (teleomorph Hypocrea jecorina) with high cellulase production was obtained by exposing the spores from T. reesei QM9414 to an ultraviolet light followed by selecting fast-growing colonies on plates containing CMC (1% w/v) as the carbon source. The mutant T. reesei RP698 reduced cultivation period to 5 days and increased tolerance to the end-products of enzymatic cellulose digestion. Under submerged fermentation conditions, FPase, CMCase, and Avicelase production increased up to 2-fold as compared to the original QM9414 strain. The highest levels of cellulase activity were obtained at 27 °C after 72 h with Avicel®, cellobiose, and sugarcane bagasse as carbon sources. The temperature and pH activity optima of the FPase, CMCase, and Avicelase were approximately 60 °C and 5.0, respectively. The cellulase activity was unaffected by the addition of 140 mM glucose in the enzyme assay. When T. reesei RP698 crude extract was supplemented by the addition of ß-glucosidase from Scytalidium thermophilum, a 2.3-fold increase in glucose release was observed, confirming the low inhibition by the end-product of cellulose hydrolysis. These features indicate the utility of this mutant strain in the production of enzymatic cocktails for biomass degradation.

Production and characterization of a thermostable antifungal chitinase secreted by the filamentous fungus Aspergillus niveus under submerged fermentation.

The filamentous fungus Aspergillus niveus produced extracellular antifungal chitinase when cultured under submerged fermentation (SbmF) using crab shells as the carbon source. Maximal chitinase production was achieved at 192 h of cultivation using minimal medium containing 1% chitin. The enzyme was purified 1.97-fold with 40% recovery by ammonium sulfate precipitation and Sephadex G-100 gel filtration. The molecular mass was estimated to be 44 kDa by both 12% SDS-PAGE and Sepharose CL-6B gel filtration. Maximal A. niveus chitinase activity was obtained at 65 °C and pH 5.0. The enzyme was fully stable at 60 °C for up to 120 min and the enzymatic activity was increased by Mn2+. In the presence of reducing and denaturing compounds, the enzyme activity was not drastically affected. The chitinase was able to hydrolyze colloidal chitin, azure chitin, and 4-nitrophenyl N-acetyl-ß-D glucosaminide; for the latter, the K0.5 and maximal velocity (Vmax) were 3.51 mM and 9.68 U/mg of protein, respectively. The A. niveus chitinase presented antifungal activity against Aspergillus niger (MIC = 84 µg/mL), A. fumigatus (MIC = 21 µg/mL), A. flavus (MIC = 24 µg/mL), A. phoenicis (MIC = 24 µg/mL), and Paecilomyces variotii (MIC = 21 µg/mL). The fungus A. niveus was able to produce a thermostable and denaturation-resistant chitinase able to inhibit fungal development, signaling its biotechnological potential.

Characterization of Aspergillus fumigatus CAS-21 tannase with potential for propyl gallate synthesis and treatment of tannery effluent from leather industry.

One of the tannase isoforms produced by the fungus Aspergillus fumigatus CAS-21 under submerged fermentation (SbmF) was purified 4.9-fold with a 10.2% recovery. The glycoprotein (39.1% carbohydrate content) showed an estimated molecular mass of 60 kDa. Optimum temperature and pH for its activity were 30-40 °C and 5.0, respectively. It showed a half-life (t50) of 60 min at 45 and 50 °C, and it was stable at pH 5.0 and 6.0 for 3 h. The tannase activity was insensitive to most salts used, but it reduced in the presence of Fe2(SO4)3 and FeCl3. On contrary, in presence of SDS, Triton-X100, and urea the enzyme activity increased. The Km value indicated high affinity for propyl gallate (3.61 mmol L-1) when compared with tannic acid (6.38 mmol L-1) and methyl gallate (6.28 mmol L-1), but the best Kcat (362.24 s-1) and Kcat/Km (56.78 s-1 mmol-1 L) were obtained for tannic acid. The purified tannase reduced 89 and 25% of tannin content of the leather tannery effluent generated by manual and mechanical processing, respectively, after 2-h treatment. The total phenolic content was also reduced. Additionally, the enzyme produced propyl gallate, indicating its ability to do the transesterification reaction. Thus, A. fumigatus CAS-21 tannase presents interesting properties, especially the ability to degrade tannery effluent, highlighting its potential in biotechnological applications.

A halotolerant bifunctional ß-xylosidase/α-l-arabinofuranosidase from Colletotrichum graminicola: Purification and biochemical characterization.

A ß-xylosidase from Colletotrichum graminicola (Bxcg) was purified. The enzyme showed high halotolerance, retaining about 63% of the control activity in the presence of 2.5molL-1 NaCl. The presence of NaCl has not affected the optimum reaction temperature (65°C), but the optimum pH was slightly altered (from 4.5 to 5.0) at high salt concentrations. Bxcg was fully stable at 50°C for 24h and over a wide pH range even in the presence of NaCl. In the absence of salt Bxcg hydrolyzed p-nitrophenyl-ß-d-xylopyranoside with maximum velocity of 348.8±11.5Umg-1 and high catalytic efficiency (1432.7±47.3Lmmol-1s-1). Bxcg revealed to be a bifunctional enzyme with both ß-xylosidase and α-l-arabinofuranosidase activities, and hydrolyzed xylooligosaccharides containing up to six pentose residues. The enzyme showed high synergistic effect (3.1-fold) with an endo-xylanase for the hydrolysis of beechwood xylan, either in the absence or presence of 0.5molL-1 NaCl, and was tolerant to different organic solvents and surfactants. This is the first report of a halotolerant bifunctional ß-xylosidase/α-l-arabinofuranosidase from C. graminicola, and the enzyme showed attractive properties for application in lignocellulose hydrolysis, particularly under high salinity and/or in the presence of residues of pretreatment steps.

Overexpression of a Cellobiose-Glucose-Halotolerant Endoglucanase from Scytalidium thermophilum.

Enzyme reaction products and by-products from pretreatment steps can inhibit endoglucanases and are major factors limiting the efficiency of enzymatic lignocellulosic biomass hydrolysis. The gene encoding the endoglucanase from Scytalidium thermophilum (egst) was cloned and expressed as a soluble protein in Pichia pastoris GS115. The recombinant enzyme (Egst) was monomeric (66 kDa) and showed an estimated carbohydrate content of 53.3% (w/w). The optimum temperature and pH of catalysis were 60-70 °C and pH of 5.5, respectively. The enzyme was highly stable at pH 3.0-8.0 with a half-life in water of 100 min at 65 °C. The Egst presented good halotolerance, retaining 84.1 and 71.4% of the control activity in the presence of 0.5 and 2.0 mol L-1 NaCl, respectively. Hydrolysis of medium viscosity carboxymethylcellulose (CMC) by Egst was stimulated 1.77-, 1.84-, 1.64-, and 1.8-fold by dithiothreitol, ß-mercaptoethanol, cysteine, and manganese at 10, 10, 10, and 5 mmol L-1 concentration, respectively. The enzyme hydrolyzed CMC with maximal velocity and an apparent affinity constant of 432.10 ± 16.76 and 10.5 ± 2.53 mg mL-1, respectively. Furthermore, the Egst was tolerant to reaction products and able to act on pretreated fractions sugarcane bagasse demonstrating excellent properties for application in the hydrolysis of lignocellulosic biomass.

Engineering the GH1 ß-glucosidase from Humicola insolens: Insights on the stimulation of activity by glucose and xylose.

The activity of the GH1 ß-glucosidase from Humicola insolens (Bglhi) against p-nitrophenyl-ß-D-glucopyranoside (pNP-Glc) and cellobiose is enhanced 2-fold by glucose and/or xylose. Kinetic and transglycosylation data showed that hydrolysis is preferred in the absence of monosaccharides. Stimulation involves allosteric interactions, increased transglycosylation and competition of the substrate and monosaccharides for the -1 glycone and the +1/+2 aglycone binding sites. Protein directed evolution has been used to generate 6 mutants of Bglhi with altered stimulation patterns. All mutants contain one of three substitutions (N235S, D237V or H307Y) clustered around the +1/+2 aglycone binding sites. Two mutants with the H307Y substitution preferentially followed the transglycosylation route in the absence of xylose or glucose. The strong stimulation of their pNP-glucosidase and cellobiase activities was accompanied by increased transglycosylation and higher monosaccharide tolerance. The D237V mutation favoured hydrolysis over transglycosylation and the pNP-glucosidase activity, but not the cellobiase activity, was stimulated by xylose. The substitution N235S abolished the preference for hydrolysis or transglycosylation; the cellobiase, but not the pNP-glucosidase activity of the mutants was strongly inhibited by xylose. Both the D237V and N235S mutations lowered tolerance to the monosaccharides. These results provide evidence that the fine modulation of the activity of Bglhi and mutants by glucose and/or xylose is regulated by the relative affinities of the glycone and aglycone binding sites for the substrate and the free monosaccharides.

Purification and functional properties of a novel glucoamylase activated by manganese and lead produced by Aspergillus japonicus.

Microbial amylases are used to produce ethanol, glucose and can be applied in textiles products, detergents and other industries. This study aimed to determine the best carbon source concentration to induce the amylase production by A. japonicus, and its purification and biochemical characterization. For that, this fungus was cultivated in Khanna medium, pH 5.5, for 4 days, at 25°C, in static condition, supplemented with potato starch and maltose in different concentrations. The fungal crude enzymatic extract was purified in a unique elution in DEAE-cellulose column and the molecular mass was determined as 72kDa. The optimum temperature and pH was 65°C and 5.0, respectively. Amylase remained 75% of its activity after one hour at 50°C and was stable in the pH range 3.0-7.0. The analysis of the end-products by thin layer chromatography showed only glucose formation, which characterizes the purified enzyme as a glucoamylase. Amylopectin was the best substrate for the enzyme assay and Mn+2 and Pb+2 were good glucoamylase activators. This activation, in addition to the biochemical characteristics are important results for future biotechnological applications of this glucoamylase in the recycling and deinking process by the paper industries.

Bioprospection and characterization of the amylolytic activity by filamentous fungi from Brazilian Atlantic Forest / Bioprospecção e caracterização da atividade amilolítica de fungos filamentosos da Mata Atlântica Brasileira

Abstract Filamentous fungi are widely diverse and ubiquitous organisms. Such biodiversity is barely known, making room for a great potential still to be discovered, especially in tropical environments - which are favorable to growth and species variety. Filamentous fungi are extensively applied to the production of industrial enzymes, such as the amylases. This class of enzymes acts in the hydrolysis of starch to glucose or maltooligosaccharides. In this work twenty-five filamentous fungi were isolated from samples of decomposing material collected in the Brazilian Atlantic Forest. The two best amylase producers were identified as Aspergillus brasiliensis and Rhizopus oryzae. Both are mesophilic, they grow well in organic nitrogen-rich media produce great amounts of glucoamylases. The enzymes of A. brasiliensis and R. oryzae are different, possibly because of their phylogenetical distance. The best amylase production of A. brasiliensis occurred during 120 hours with initial pH of 7.5; it had a better activity in the pH range of 3.5-5.0 and at 60-75°C. Both fungal glucoamylase had wide pH stability (3-8) and were activated by Mn2+. R. oryzae best production occurred in 96 hours and at pH 6.5. Its amylases had a greater activity in the pH range of 4.0-5.5 and temperature at 50-65ºC. The most significant difference between the enzymes produced by both fungi is the resistance to thermal denaturation: A. brasiliensis glucoamylase had a T50 of 60 minutes at 70ºC. The R. oryzae glucoamylase only had a residual activity when incubated at 50°C with a 12 min T50.

Resumo Fungos filamentosos são organismos amplamente diversificados e ubíquos. Esta biodiversidade ainda é pouco caracterizada, desta forma, há um grande potencial a ser descoberto, sobretudo em biomas tropicais, que favorecem o crescimento e diversificação de espécies. Fungos filamentosos são extensivamente utilizados para a produção industrial de enzimas, como as amilases. Esta classe de enzimas atua na hidrólise do amido em glicose ou maltooligossacarídeos. Neste trabalho 25 cepas de fungos filamentosos foram isoladas a partir de amostras de material em decomposição coletados na Mata Atlântica Brasileira. As duas cepas que produziram mais amilases foram identificadas como Aspergillus brasiliensis e Rhizopus oryzae. Ambos os fungos são mesofílicos, crescem bem em meio de cultivo rico em nitrogênio orgânico, e produziram grande quantidade de glucoamilase. As enzimas de A. brasiliensis e R. oryzae possuem características distintas, possivelmente devido à distância filogenética das espécies. A produção de amilase mais expressiva de A. brasiliensis ocorreu em 120 horas de cultivo e pH inicial de 7,5; possui maior atividade em temperaturas entre 60-75ºC e pH entre 3,5-5,0. Ambas glucoamilases fúngicas obtiveram ampla estabilidade de pH (3-8) e foram ativadas por Mn2+. A melhor produção de R. oryzae ocorreu em 96 horas de cultivo e pH 6,5. Suas amilases são mais ativas na faixa de pH de 4,0-5,5 e temperatura entre 50-60ºC. A diferença mais significativa dentre as enzimas produzidas pelos fungos selecionados é a resistência à desnaturação térmica, tendo a glucoamilase de A. brasiliensis um T50 de 60 minutos a 70ºC, já a glucoamilase de R. oryzae somente obteve atividade residual quando incubada a 50°C, com um T50 de apenas 12 minutos.

Biochemical effect of a histidine phosphatase acid (phytase) of Aspergillus japonicus var. Saito on performance and bony characteristics of broiler.

Phytases are enzymes that hydrolyze the ester linkage of phytic acid, releasing inositol and inorganic phosphate. The phytic acid (phytate) is a major form of phosphorus in plant foods. Knowing that diet for animal of production has the cereal base (corn and soybean), primarily, broilers need for an alternative to use of the phosphate present in these ingredients, since it does not naturally produce the enzyme phytase, which makes it available. The aims of this work was studding the safe supplementation of Aspergillus japonicus var. Saito crude phytase in feeding broilers and check the biochemical effect on performance and bones of these animals. The enzymatic extract did not have aflatoxins B1, B2, G2 and G1 and zearalenone and ochratoxin, and low concentrations of this extract did not have cytotoxic effects on cells derived from lung tissue. The in vivo experiments showed that the phytase supplied the available phosphate reduction in the broiler feed formulation, with a live weight, weight gain, feed intake, feed conversion, viability, productive efficiency index and carcass yield similar to the control test. Furthermore, the phytase supplementation favored the formation of bone structure and performance of the broilers. The results show the high biotechnological potential of A. japonicus phytase on broiler food supplementation to reduce phosphorus addition in the food formulation. So, this enzyme could be used as a commercial alternative to animal diet supplementation.

The functional properties of a xyloglucanase (GH12) of Aspergillus terreus expressed in Aspergillus nidulans may increase performance of biomass degradation.

Filamentous fungi are attractive hosts for heterologous protein expression due to their capacity to secrete large amounts of enzymes into the extracellular medium. Xyloglucanases, which specifically hydrolyze xyloglucan, have been recently applied in lignocellulosic biomass degradation and conversion in many other industrial processes. In this context, this work aimed to clone, express, and determine the functional properties of a recombinant xyloglucanase (AtXEG12) from Aspergillus terreus, and also its solid-state (SSF) and submerged (SmF) fermentation in bioreactors. The purified AtXEG12 showed optimum pH and temperature of 5.5 and 65 °C, respectively, demonstrating to be 90 % stable after 24 h of incubation at 50 °C. AtXEG12 activity increased in the presence of 2-mercaptoethanol (65 %) and Zn+2 (45 %), while Cu+2 and Ag+ ions drastically decreased its activity. A substrate assay showed, for the first time for this enzyme's family, xylanase activity. The enzyme exhibited high specificity for tamarind xyloglucan (K M 1.2 mg mL-1) and V max of 17.4 µmol min-1 mg-1 of protein. The capillary zone electrophoresis analysis revealed that AtXEG12 is an endo-xyloglucanase. The heterologous xyloglucanase secretion was greater than the production by wild-type A. terreus cultivated in SmF. On the other hand, AtXEG12 activity reached by SSF was sevenfold higher than values achieved by SmF, showing that the expression of recombinant enzymes can be significantly improved by cultivation under SSF.

Characterization of a Thermotolerant Phytase Produced by Rhizopus microsporus var. microsporus Biofilm on an Inert Support Using Sugarcane Bagasse as Carbon Source.

The Rhizopus microsporus var. microsporus biofilm was able to produce increased levels of an extracellular thermotolerant phytase using polyethylene and viscose as an inert support in both modified NBRIP medium and modified Khanna medium containing sugarcane bagasse as the carbon source. The enzyme production was strictly regulated by the phosphorus content with optimal production at 0.5 mM of sodium phytate and KH2PO4. The extracellular phytase, RMPhy1, was purified 4.18-fold with 4.78 % recovery using DEAE-cellulose and CM-cellulose. A single protein band with a molecular mass of 35.4 kDa was obtained when the samples were subjected to 10 % SDS-PAGE. The optimum temperature for activity was 55 °C and the optimum pH was 4.5. R. microsporus var. microsporus phytase exhibited high stability at 30 and 40 °C with a half-life of 115 min at 60 °C. The enzyme activity increased in the presence of Ca (2+) and was inhibited by Zn(2+), arsenate, and sodium phosphate. Phytase demonstrated high substrate specificity for sodium phytate with K m = 0.72 mM and V max = 94.55 U/mg of protein and for p-NPP with K m = 0.04 mM and V max = 106.38 U/mg of protein. The enzyme also hydrolyzed ATP, AMPc, glucose 6-phosphate, glucose 1-phosphate, and UDPG. This is the first report on phytase characterization delivered with biofilm technology. The properties of the enzyme account for its high potential for use in biotechnology and the possibility of application in different industrial sectors as feed in the future.

Secretome Analysis of Metarhizium anisopliae Under Submerged Conditions Using Bombyx mori Chrysalis to Induce Expression of Virulence-Related Proteins.

The entomopathogenic fungus Metarhizium anisopliae is used to control insect pests. This species is specialized for the secretion of an enzymatic complex consisting of proteases, lipases, and chitinases related to pathogenicity and virulence. In this context, the secretomes of strains IBCB 167 and IBCB 384 of M. anisopliae var. anisopliae, grown under submerged fermentation in the presence of chrysalis as an inducer, were analyzed. Analysis of two-dimensional gels showed qualitative and quantitative differences between secreted proteins in both isolates. Around 102 protein spots were analyzed, and 76 % of the corresponding proteins identified by mass spectrometry were grouped into different classes (hydrolases, oxidases, reductases, isomerases, kinases, WSC domains, and hypothetical proteins). Thirty-three per cent of all the proteins analyzed were found to be common in both strains. Several virulence-related proteins were identified as proteases and mannosidases. Endo-N-acetyl-ß-D-glucosaminidase expression was observed to be 10.14-fold higher for strain IBCB 384 than for strain IBCB 167, which may be an important contributor to the high virulence of IBCB 384 in Diatraea ssaccharalis. These results are important for elucidation of the host-pathogen relationship and the differences in virulence observed between the two strains.

Characterization of a multi-tolerant tannin acyl hydrolase II from Aspergillus carbonarius produced under solid-state fermentation

Background Tannases are enzymes with biotechnological potential produced mainly by microorganisms as filamentous fungi. In this context, the production and characterization of a multi-tolerant tannase from Aspergillus carbonarius is described. Results The filamentous fungus A. carbonarius produced high levels of tannase when cultivated under solid-state fermentation using green tea leaves as substrate/carbon source and tap water at a 1:1 ratio as the moisture agent for 72 h at 30°C. Two tannase activity peaks were obtained during the purification step using DEAE-Cellulose. The second peak (peak II) was purified 11-fold with 14% recovery from a Sepharose CL-6B chromatographic column. The tannase from peak II (tannase II) was characterized as a heterodimeric glycoprotein of 134.89 kDa, estimated through gel filtration, with subunits of 65 kDa and 100 kDa, estimated through SDS-PAGE, and 48% carbohydrate content. The optimal temperature and pH for tannase II activity was 60°C and 5.0, respectively. The enzyme was fully stable at temperatures ranging from 20-60°C for 120 min, and the half-life (T1/2) at 75°C was 62 min. The activation energy was 28.93 kJ/mol. After incubation at pH 5.0 for 60 min, 75% of the enzyme activity was maintained. However, enzyme activity was increased in the presence of AgNO3 and it was tolerant to solvents and detergents. Tannase II exhibited a better affinity for methyl gallate (Km = 1.42 mM) rather than for tannic acid (Km = 2.2 mM). Conclusion A. carbonarius tannase presented interesting properties as, for example, multi-tolerance, which highlight its potential for future application.

Screening of thermotolerant and thermophilic fungi aiming β-xylosidase and arabinanase production

Plant cell wall is mainly composed by cellulose, hemicellulose and lignin. The heterogeneous structure and composition of the hemicellulose are key impediments to its depolymerization and subsequent use in fermentation processes. Thus, this study aimed to perform a screening of thermophilic and thermotolerant filamentous fungi collected from different regions of the São Paulo state, and analyze the production of β-xylosidase and arabinanase at different temperatures. These enzymes are important to cell wall degradation and synthesis of end products as xylose and arabinose, respectively, which are significant sugars to fermentation and ethanol production. A total of 12 fungal species were analyzed and 9 of them grew at 45 ºC, suggesting a thermophilic or thermotolerant character. Additionally Aspergillus thermomutatus anamorph of Neosartorya and A. parasiticus grew at 50 ºC. Aspergillus niger and Aspergillus thermomutatus were the filamentous fungi with the most expressive production of β-xylosidase and arabinanase, respectively. In general for most of the tested microorganisms, β-xylosidase and arabinanase activities from mycelial extract (intracellular form) were higher in cultures grown at high temperatures (35-40 ºC), while the correspondent extracellular activities were favorably secreted from cultures at 30 ºC. This study contributes to catalogue isolated fungi of the state of São Paulo, and these findings could be promising sources for thermophilic and thermotolerant microorganisms, which are industrially important due to their enzymes.

Structural basis for glucose tolerance in GH1 ß-glucosidases.

Product inhibition of ß-glucosidases (BGs) by glucose is considered to be a limiting step in enzymatic technologies for plant-biomass saccharification. Remarkably, some ß-glucosidases belonging to the GH1 family exhibit unusual properties, being tolerant to, or even stimulated by, high glucose concentrations. However, the structural basis for the glucose tolerance and stimulation of BGs is still elusive. To address this issue, the first crystal structure of a fungal ß-glucosidase stimulated by glucose was solved in native and glucose-complexed forms, revealing that the shape and electrostatic properties of the entrance to the active site, including the +2 subsite, determine glucose tolerance. The aromatic Trp168 and the aliphatic Leu173 are conserved in glucose-tolerant GH1 enzymes and contribute to relieving enzyme inhibition by imposing constraints at the +2 subsite that limit the access of glucose to the -1 subsite. The GH1 family ß-glucosidases are tenfold to 1000-fold more glucose tolerant than GH3 BGs, and comparative structural analysis shows a clear correlation between active-site accessibility and glucose tolerance. The active site of GH1 BGs is located in a deep and narrow cavity, which is in contrast to the shallow pocket in the GH3 family BGs. These findings shed light on the molecular basis for glucose tolerance and indicate that GH1 BGs are more suitable than GH3 BGs for biotechnological applications involving plant cell-wall saccharification.

A novel ß-glucosidase from Humicola insolens with high potential for untreated waste paper conversion to sugars.

Humicola insolens produced a new ß-glucosidase (BglHi2) under solid-state fermentation. The purified enzyme showed apparent molecular masses of 116 kDa (sodium dodecyl sulfate-polyacrylamide gel electrophoresis) and 404 kDa (gel-filtration), suggesting that it is a homotetramer. Mass spectrometry analysis showed amino acid sequence similarity with a ß-glucosidase from Chaetomium thermophilum. Optima of pH and temperature were 5.0 and 65 °C, respectively, and the enzyme was stable for 60 min at 50 °C, maintaining 71 % residual activity after 60 min at 55 °C. BglHi2 hydrolyzed p-nitrophenyl-ß-D-glucopyranoside and cellobiose. Cellobiose hydrolysis occurred with high apparent affinity (K M = 0.24 ± 0.01 mmol L(-1)) and catalytic efficiency (k cat/K M = 1,304.92 ± 53.32 L mmol(-1) s(-1)). The activity was insensitive to Fe(+3), Cr(+2), Mn(+2), Co(+2), and Ni(2+), and 50-60 % residual activities were retained in the presence of Pb(2+), Hg(2+), and Cu(2+). Mixtures of pure BglHi2 or H. insolens crude extract (CE) with crude extracts from Trichoderma reesei fully hydrolyzed Whatman no. 1 paper. Mixtures of H. insolens CE with T. reesei CE or Celluclast 1.5 L fully hydrolyzed untreated printed office paper, napkin, and magazine papers after 24-48 h, and untreated cardboard was hydrolyzed by a H. insolens CE/T. reesei CE mixture with 100 % glucose yield. Data revealed the good potential of BglHi2 for the hydrolysis of waste papers, promising feedstocks for cellulosic ethanol production.

Screening of thermotolerant and thermophilic fungi aiming ß-xylosidase and arabinanase production.

Plant cell wall is mainly composed by cellulose, hemicellulose and lignin. The heterogeneous structure and composition of the hemicellulose are key impediments to its depolymerization and subsequent use in fermentation processes. Thus, this study aimed to perform a screening of thermophilic and thermotolerant filamentous fungi collected from different regions of the São Paulo state, and analyze the production of ß-xylosidase and arabinanase at different temperatures. These enzymes are important to cell wall degradation and synthesis of end products as xylose and arabinose, respectively, which are significant sugars to fermentation and ethanol production. A total of 12 fungal species were analyzed and 9 of them grew at 45 °C, suggesting a thermophilic or thermotolerant character. Additionally Aspergillus thermomutatus anamorph of Neosartorya and A. parasiticus grew at 50 °C. Aspergillus niger and Aspergillus thermomutatus were the filamentous fungi with the most expressive production of ß-xylosidase and arabinanase, respectively. In general for most of the tested microorganisms, ß-xylosidase and arabinanase activities from mycelial extract (intracellular form) were higher in cultures grown at high temperatures (35-40 °C), while the correspondent extracellular activities were favorably secreted from cultures at 30 °C. This study contributes to catalogue isolated fungi of the state of São Paulo, and these findings could be promising sources for thermophilic and thermotolerant microorganisms, which are industrially important due to their enzymes.

A novel glucoamylase activated by manganese and calcium produced in submerged fermentation by Aspergillus phoenicis.

This study investigates the production of glucoamylase from Aspergillus phoenicis in Machado Benassi (MB) medium using 1% maltose as carbon source. The maximum amylase activity was observed after four days of cultivation, on static conditions at 30 °C. Glucoamylase production was induced by maltose and inhibited by different glucose concentrations. The optimum of temperature and pH were 60-65 °C, and 4.5 or 5.0 to sodium acetate and Mcllvaine buffers, respectively. It was observed that the enzyme was totally stable at 30-65 °C for 1 h, and the pH range was 3.0-6.0. The enzyme was mainly activated by manganese (176%), and calcium (130%) ions. The products of starch hydrolysis were analyzed by thin layer chromatography and after 3 h, only glucose was detected, characterizing the amylolytic activity as a glucoamylase.

Increase of the phytase production by Aspergillus japonicus and its biocatalyst potential on chicken feed treatment.

Phytase hydrolyzes phytic acid from the plant components of animal feed, releasing inorganic phosphorus. The phytase production by Aspergillus japonicus was optimized using Plackett-Burman designs (PBD), composite central rotational designs (CCRD), and response surface methodology from standard Czapek medium. The enzyme was applied in broiler chicken and laying hen foods. Analysis from PBD showed that KH2 PO2, MgSO4 · 7H2O, and yeast extract had significant influences on phytase secretion (p < 0.05). The best results from the CCRD experiments were obtained using (A) 0.040% KH2 PO4, (B) 0.050% MgSO4 · 7H2O, and (C) 0.040% yeast extract, enhancing in 49-53 U mg(-1) protein. The determination coefficient (R(2)) was 0.92 and Fcalc was 7.48 times greater than Flisted . Thus, the reduced coded model: Y (U mg-1) = 50.29 + 4.30A - 3.35(A)2 - 4.80(B)2 + 5.62C - 4.26(C)2 was considered predictive and statistically significant (p < 0.05). The optimized culture medium increased the phytase yield in 250%. A. japonicus phytase released high levels of Pi from broiler chicken and laying hen food. A. japonicus is an excellent phytase producer in a culture medium using inexpensive components and agricultural wastes. Therefore, these results provide sound arguments for the formulation of a low cost culture medium for phytase production.

Characterization of the co-purified invertase and ß-glucosidase of a multifunctional extract from Aspergillus terreus.

The filamentous fungus Aspergillus terreus secretes both invertase and ß-glucosidase when grown under submerged fermentation containing rye flour as the carbon source. The aim of this study was to characterize the co-purified fraction, especially the invertase activity. An invertase and a ß-glucosidase were co-purified by two chromatographic steps, and the isolated enzymatic fraction was 139-fold enriched in invertase activity. SDS-PAGE analysis of the co-purified enzymes suggests that the protein fraction with invertase activity was heterodimeric, with subunits of 47 and 27 kDa. Maximal invertase activity, which was determined by response surface methodology, occurred in pH and temperature ranges of 4.0-6.0 and 55-65 °C, respectively. The invertase in co-purified enzymes was stable for 1 h at pH 3.0-10.0 and maintained full activity for up to 1 h at 55 °C when diluted in water. Invertase activity was stimulated by 1 mM concentrations of Mn²âº (161 %), Co²âº (68 %) and Mg²âº (61 %) and was inhibited by Al³âº, Ag⁺, Fe²âº and Fe³âº. In addition to sucrose, the co-purified enzymes hydrolyzed cellobiose, inulin and raffinose, and the apparent affinities for sucrose and cellobiose were quite similar (K(M) = 22 mM). However, in the presence of Mn²âº, the apparent affinity and V(max) for sucrose hydrolysis increased approximately 2- and 2.9-fold, respectively, while for cellobiose, a 2.6-fold increase in V(max) was observed, but the apparent affinity decreased 5.5-fold. Thus, it is possible to propose an application of this multifunctional extract containing both invertase and ß-glucosidase to degrade plant biomass, thus increasing the concentration of monosaccharides obtained from sucrose and cellobiose.